The present study investigated the effects of forage cutting and baler mixing on the chemical compositions, fermentation indices, and aerobic stability of whole crop rice (WCR) haylage. The WCR (“Youngwoo”) was harvested at 48.4% dry matter and ensiled into a 300 kg bale silo with forage cutting (whole crop without cutting vs. 5 cm of cutting length). The WCR forages were ensiled without baler mixing process (CON) or with (MIX). The concentrations of dry matter, crude protein, ether extract, crude ash, neutral detergent fiber, and acid detergent fiber of whole crop rice before ensiling were 48.4, 9.70, 2.57, 6.11, 41.2, and 23.5%, respectively. The forage cutting did not affect the chemical compositions, fermentation indices, microbes, and aerobic stability of WCR haylage (p>0.05). The CON haylages tend to be higher in NDF content (p<0.10). The MIX haylages had lower in lactate (p=0.019), and lactate:acetate ratio (p<0.001). The MIX haylages had higher in lactic acid bacteria (LAB) (p=0.010). Therefore, this study concluded that the fermentation quality of WCR haylage improved by baler mixing, but had no effects by forage cutting.

Near infrared spectroscopy (NIRS) is a rapid and accurate method for analyzing the quality of cereals, and dried animal forage. However, one limitation of this method is its inability to measure fermentation parameters in dried and ground samples because they are volatile, and therefore, respectively lost during the drying process. In order to overcome this limitation, in this study, fresh coarse haylage was used to test the potential of NIRS to accurately determine chemical composition and fermentation parameters. Fresh coarse Italian ryegrass haylage samples were scanned at 1 nm intervals over a wavelength range of 680 to 2500 nm, and optical data were recorded as log 1/reflectance. Spectral data, together with first- and second-order derivatives, were analyzed using partial least squares (PLS) multivariate regressions; scatter correction procedures (standard normal variate and detrend) were used in order to reduce the effect of extraneous noise. Optimum calibrations were selected based on their low standard error of cross validation (SECV) values. Further, ratio of performance deviation, obtained by dividing the standard deviation of reference values by SECV values, was used to evaluate the reliability of predictive models. Our results showed that the NIRS method can predict chemical constituents accurately (correlation coefficient of cross validation, R2 cv, ranged from 0.76 to 0.97); the exception to this result was crude ash (R2 cv = 0.49 and RPD = 2.09). Comparison of mathematical treatments for raw spectra showed that second-order derivatives yielded better predictions than first-order derivatives. The best mathematical treatment for DM, ADF, and NDF, respectively was 2, 16, 16, whereas the best mathematical treatment for CP and crude ash, respectively was 2, 8, 8. The calibration models for fermentation parameters had low predictive accuracy for acetic, propionic, and butyric acids (RPD < 2.5). However, pH, and lactic and total acids were predicted with considerable accuracy (R2 cv 0.73 to 0.78; RPD values exceeded 2.5), and the best mathematical treatment for them was 1, 8, 8. Our findings show that, when fresh haylage is used, NIRS-based calibrations are reliable for the prediction of haylage characteristics, and therefore useful for the assessment of the forage quality.

The present study was carried out to explore the potential effects of novel lactic acid bacteria Pediococcus penticeous KCC-23 (KCC-23) and Lactobacillus plantarum KCC-24 (KCC-24) on rye haylage fermentation at National Institute of Animal Science, Cheonan province in Korea. The experiment contains three different groups such as control without lactic acid bacteria, rye haylage with KCC-23 and rye haylage KCC-24. After experimental periods, the content of crude protein, acid detergent fiber (ADF), neutral detergent fiber (NDF), the activity of total digestible nutrient (TDN) and In-vitro digestibility (IVD) was similar in control and LAB treated haylage (p<0.05). The pH was reduced in KCC-23 and KCC-24 treated rye haylage as compared to control (p<0.05). The lactic acid concentration in haylages was increased by L. plantarum KCC-23, and KCC-24 supplement. Whereas, the less amount of acetic acid and butyric acid was noted in KCC-23 and KCC-24 treated haylage as compared with control (p<0.05). The KCC-23 and KCC-24 were dominantly grown in experimental haylage as compared with control. It indicates, the addition of KCC-23, and KCC-24 enhances fermentation quality of haylages as compared control. The present study suggests that KCC-23 and KCC-24 are potent strains that were improving the fermentation process in rye haylage

본 연구는 국내에서 헤일리지의 생산 및 이용 확대를 위해 수분함량에 따른 헤일리지의 사료가치 및 발효품질의 변화를 구명하고 양질의 헤일리지 생산 확대를 위한 기초 자료를 확보하기위하여 2011년 9월부터 2012년 12월까지 충남 천안시 소재 국립축산과학원 초지사료과 시험포장에서 수행되었다. 수분함량이 다양한 헤일리지의 조제를 위해 이탈리안 라이그라스의 ‘코윈어리’ 품종을 이용하여 수분함량 60~30%까지 5% 차이로 총 7처리로 헤일리지를 조제하였다. 수분함량이 다른 이탈리안 라이그라스 헤일리지의 사료가치는 수분함량에 따라 유의적인 차이를 나타내지 않았다. 수분함량에 따른 발효품질의 변화는 수분함량의 차이에 따라 유의적인 차이를 보였으며 상대적으로 수분함량이 높은 조건(>40%)에서 발효품질이 우수하였으며 수분함량이 낮은 조건에서는 발효품질도 낮은 것으로 나타났다. 수분함량별 헤일리지의 유기산 구성비율은 수분함량이 상대적으로 높은 조건(>40%)에서 젖산비율이 높게 나타났으며 수분함량이 낮은 조건(<40%)에서는 젖산비율이 감소하고 초산과 낙산비율이 높아지는 것으로 나타났다. 이상의 결과를 종합해 보면 안정적인 헤일리지 생산을 위해 발효품질을 고려해보면 수분함량이 40%가 헤일리지 조제의 한계점으로 사료되며 추후 헤일리지의 장기 저장성 검토 및 저 수분 조건에서 발효품질 개선을 위한 추가적인 연구가 진행되어야 할 것으로 생각된다.

이 연구는 동계 사료맥류를 활용하여 건초대용 양질 헤일리지의 생산 가능성을 검토하기위하여 맥종별 수확시기, 적정 건조시간 및 헤일리지 품질을 분석하였다. 그 결과 수확시기가 늦어질수록 건물수량과 TDN 수량은 높아지는 경향이었고, 단백질과 NDF, ADF 함량은 낮아지는 경향을 보였다(p<0.05). 헤일리지 조제를 위한 건조시간은 청보리, 귀리, 트리티케일,총체밀 모두 유숙기에는 수분함량이 높음과 동시에 기상온도도 높지 않으므로 32시간 이상예건이 필요하고, 황숙기에는 8~24시간 정도예건이 필요하며, 완숙기에는 예건이 필요 없었다. 호밀은 출수 후 10일에는 32시간 이상,출수 후 20일, 30일에서는 24시간 이상 예건이필요하였다. 헤일리지 발효품질에서 pH는 모든맥종에서 모두 수확시기가 늦어질수록 높아지는 경향을 보였고, 젖산함량은 유숙기에 가장높은 값을 보였고, 수확시기가 늦어질수록 감소하였다(p<0.05). 초산도 수확시기가 늦어짐에따라 감소하는 경향을 보였고, 낙산은 검출되지 않았다. 이상의 연구결과를 종합하여 볼 때,사료맥류로 헤일리지 조제 시 단백질함량이나발효품질 면에서는 수확이 빠를수록 유리하지만 우리나라 기상조건으로 볼 때 예건의 어려움이 있으므로, 호밀은 청예나 사일리지로 이용을 하고 청보리와 귀리, 트리티케일, 총체밀은 황숙기에 수확하여 8~24시간 정도 예건하면헤일리지로 이용 가능성이 있는 것으로 판단되었다.