Consumer demand for imported and craft beer is increasing. Almost all the malt used by craft beer companies is imported. This study sought to develop a malting technology to expand the use of domestic barley, the main raw material for beer, and to examine its influence on the quality of domestic malt. The Hopum cultivar of beer barley was purchased and used at the Jeollanam-do Seed Management Center. A pilot-scale malting facility built by the National Institute of Crop Science was used. One sack (40 kg) of barley was sieved through screening sieves, and the barley was classified according to size (3.1, 2.8, 2.5, 2.2, and 2.2 mm), with the size-related composition being 18.1, 48.9, 23.3, 6.4, and 1.0%, respectively. The malt yields were 89.0, 87.6, 86.6, 82.2, and 76.1%, respectively. The coleoptiles elongation decreased as the barley size decreased. The protein content of malt tended to be high at small particle sizes of 2.2 mm. The soluble solid content of wort prepared from malt revealed good values of 17.4-17.5oBx, except for 15.3oBx for particles <2.2 mm in size. According to barley size in the malting process, these findings should be valuable quality indicators of malt.

Korea depends almost entirely on imports for malt, the main ingredient in beer. However, the consumer market for domestic malt has not developed in Korea because of the prejudice that the quality of domestic malt is inferior to that of imported malt. This study aimed to analyze the quality of malt from Gwangmaeg (GM) and Hopum (HP), representative domestic beer barley varieties cultivated under varying nitrogen fertilizer application rates (standard fertilizer application, 50% increase in application, and 50% decrease in application), and use the findings as primary data to promote domestic malt consumption. GM’s crude protein and starch contents were significantly (Ρ<0.05) higher and lower, respectively, than those in HP. With decreased fertilizer application (GM: 14.0±0.8% and HP: 11.4±0.4%), the protein content was significantly lower than that with increased fertilizer application (GM: 15.5± 0.3% and HP: 13.1±1.3%). Although there was no difference in -glucan content, starch content tended to increase, indicating quality improvement. Acrospire length, yield, and enzyme titer, quality indicators of malt, increased with further fertilizer application, whereas friability and Kolbach index increased with decreased fertilizer application. For wort qualities, filtration time decreased from 36 to 34 minutes in GM and 55 to 42 minutes in HP, with the wort extraction rate increasing with decreased fertilizer application. These findings showed that decreased nitrogen fertilizer application improves the qualities of malt and wort.

본 연구에서는 국내 육성 보리를 이용한 엿기름의 최적 품종 선정 및 품질 유지 기술 개발을 위한 기초기반연구로 시판 엿기름을 수집하여 제품에 사용된 원료 조성을 분석하고, 효소활성 및 품질 특성을 비교분석하였다. 본 연구에서 사용한 21개의 엿기름 제품 중 12개는 100% 보리로 만든 엿기름이었다. 특히 모든 엿기름의 원료에 대한 품종정보를 제시한 제품은 전무하였다. 엿기름 21종의 일반성분 분석 결과, 수분 4.91~11.99%, 지방 1.71~2.48%, 단백질 7.80~11.97%, 탄수화물 73.64~82.24%, 총 전분 5.50~8.22%, 환원당 3.64~14.44%로 제품 간의 성분 차이가 다르게 나타났다. 엿기름의 효소활성을 측정한 결과, 당화력은 36.80~94.30°, α-amylase 및 β- amylase 활성은 각각 18.17~186.50 및 6.53~25.05 unit/g의 범위를 보여 제품별로 활성의 차이가 큰 것을 확인할 수 있었다. 본 연구에서 도출된 시판 엿기름의 품질 분석 결과를 토대로 엿기름 제조에 적합한 최적 품종 선정 및 품질 유지 기술개발을 위한 기초자료로 유용할 것으로 판단된다.

Barley breeding program of RDA (Rural Development Administration) has been develop to new hulled barley variety that has been used for malt and beer material. Through this program, we developed new two-rowed covered barley, Imaeg, with disease resistant, lodging tolerant and good malt quality for beer and Korean traditional drink ‘Sikhye’ in 2013. Imaeg showed resistant to Barley yellow mosaic virus (BaYMV), lodging tolerant and early maturing. The regional yield trials were conducted for Imaeg as a breeding line ‘Iksan166’ during three years at four different regions. And then it was registered to Plant protection right, No. 5681 in 2015 after field experiment by KSVS (Korea Seed & Variety Service). Imaeg has I of vernalization and shorter stem length as 77cm than 7cm to control variety Hopum. Yield potential of Imaeg about 4.8ton/ha that higher about 3% in paddy field condition than control, however, it has no significant difference. In quality examination for beer usage, Imaeg has higher 1,000 grain weight (45.6g) and higher assortment ratio (93.6%) than those of Hopum as 42.6g and 90.4% respectively. In malt quality, Imaeg showed higher soluble protein, Kolbach index and diastatic power than those of Hopum significantly. In addition, Imaeg has better ‘Sikhye’ malt quality significantly in lightness of grain (58.4 L value) and growth rate (216.8%) than those of Hopum as 54.3 (L value) and 177.5% respectively. Imaeg would be suitable for cultivation at the area above -4°C of daily minimum temperature in January in Korean peninsula.

Improvement of winter hardiness, lodging resistance and good quality have been recently received more attention by covered barley(Hordeum vulgare L.) breeders than ever in Korea. ‘Hyeyang’, a new covered barley cultivar with early maturing and high yield was developed by the National Institute of Crop Science, RDA in 2010. It was derived from the cross between‘Milyang87’and‘Wolsung8120’with good quality. The initial cross was done in 1999 and the selected line, ‘Iksan432’ (YB4494-B-B-21-2), showed high yield and good quality characteristics under yield trial test from 2008 to 2010. The following is the characteristics of‘Hyeyang’that is characterized as the vernalization of Ⅰ, green leaf, compact spike and long rough awns. The heading date of‘Hyeyang’were similar to‘Olbori’. The culm length was 82 cm which was 6 cm shorter than‘Olbori’. It showed the spike length of 4.3 cm, 798 spikes / m2, 56 grains / spike and 26.7 g for 1,000 grains weight. It showed similar winter hardiness and stronger resistance to barley yellow mosaic virus (BaYMV) compare to‘Olbori’. It showed higher diastatic power 235DP than that of check cultivar, ‘Olbori’. Average yield of ‘Hyeyang’ was 4.44 MT/ha in the regional yield trials carried out in four location at double cropping system in Korea from 2008 to 2010, which was 8 percent higher than ‘Olbori’. ‘Hyeyang’would be suitable for the area above –8℃ of daily minimum temperature in January in Korean peninsula.

The purpose of this study was to improve the functionality of a healthy drink with examining the possibility of manufacturing different enzymes (alpha-, beta-, glucose-amylase) in barley malts (BM) produced in various malting periods. The study showed that enzyme treatment increased significantly total polyphenol content (TPC), DPPH radical scavenging activity and hydroxly radical scavenging activity in malted liquid samples (MLS) which obtained from various malting periods. The highest of TPC were found in Gluco-24M with 1.981 ㎎TAE/㎖, followed by Beta-24M and Alpha-72M with 1.878 ㎎TAE/㎖ and 1.845 ㎎TAE/㎖, respectively. The DPPH result revealed that percent of inhibition increased by 71-75% compared to the control. No statistical difference was found between MLS obtained by 24 hr of malting (24 M) and 72 hr of malting (72 M) after enzyme treatment. In addition, an increasing of hydroxyl radical was in the same trend to the TPC and DPPH. The hydroxyl radical scavenging activity of enzyme treated samples was 1,5 times higher than the control. These results suggest the possibility of enzyme application to barley malts obtained in various germination periods for improving quality and functionality of barley malts.

Improvement of winter hardiness, diseases resistance and good quality have been recently received more attention by covered barley(Hordeum vulgare L.) breeders than ever in Korea. “Hyegang”, a new covered barley cultivar with similar maturing and high yield was developed by the National Institute of Crop Science, RDA in 2011. It was derived from the cross between “Milyang87/NWX-GB-G 2” and “Milyang87/Chalbori” with good quality. The initial cross was done in 2000 and the selected line, “Iksan445” (YB4625-B-B-6-2), showed high yield and good quality characteristics under yield trial test in 2008. It was cultivated three times for three years (2009～2011) in the four locations of regional yield trial (RYT) in korea and was investigated about agronomic and quality characteristics and released as “Hyegang”. The heading date was May 4 in upland and April 26 in paddy field which was 1 and 0 day lateness respectively than that of check cultivar, “Olbori”. The culm length was 77 cm which was 6 cm shorter than that with check cultivar. It showed the spike length of 4.7 cm, 800 spikes / m2, 64 grains / spike and 25.1g for 1,000 grains weight. It showed similar maturing and stronger resistance to barley yellow mosaic virus (BaYMV) compare to check cultivar. It showed higher diastatic power 216DP than that of check cultivar, ‘Olbori’. Average yield of “Hyegang” in the RYT was 4.61 MT/ha in upland and 4.38 MT/ha in paddy field, espectively.

’Jungmo-2007’ is a new two-rowed barley cultivar developed in 2011 with distinct growth and good quality characteristics, respectively, that earlier heading date, lodging tolerant and lots of tiller, high yielding, and lager kernel size, better grain assortment, higher diastic power and black malt property than those of check variety ‘Hopumbori’. This cultivar was tested the yield and regional adaptation trials for three years in 3 southern regions. The cultiavar was from artificial cross between ‘Prisma’ with short culm length and earlier maturity and ‘Milyang 114’ with high yielding and better malt quality. ‘Jungmo-2007’ showed shorten the stem length to 16% comparing with 91cm of the check, which increase the lodging tolerant. The heading date was earlier 2 to 3 days than the check. It showed larger grain character with 48.5g in 1,000 kernel weight that 45.0g of the check. 97% of grain assortment that is one of the major property for better malting was higher 2% than that of the check. The yield was higher 5% than that of the check. Most quality in raw grain and malt was similar to the check in protein content, germination potential, water sensitivity etc. Especially this cultivar has a higher diastic power as 226WK than 196WK of the check and the malt showed like a black malt appearance. These characteristics could used not for malt for beer making but other processed barley foods.

Effects of acute anoxia on carbohydrate hydrolytic enzyme activities and free amino acid contents in malt were examined. Malts were prepared with barley grains germinated for 7 days which contained the highest levels of amylolytic and(1-3,1-4)-β -glucanase activities. α -Amylase and β -amylase activities in malts were not significantly affected by anoxia for 5 or 10 h.(1-3,1-4)-β -Glucanase activity, however, decreased about 7 to 10% by anoxia for 5 or 10 h. Alanine and ~gamma -aminobutyric acid content changed drastically. Alanine contents in malts increased by 2.2- and 2-fold, and ~gamma -aminobutyric acid contents by 1.4- and 1.9-fold under anoxia for 5 and 10 h, respectively.

본 시험은 맥주맥 품종들의 수량과 맥아품질에 영향하는 질소 시비반응차를 구명할 목적으로 시도되었다. 1979년부터 1980년에 걸쳐 광주시 소재 전남대학교 농과대학 시험 포장에서 실시한 두 맥주맥 품종(Golden Melon과 향맥)의 질소시비(3, 6, 9, 12 및 15kg ai/10a) 반응은 다음과 같이 나타났다. 1. 질소 시비로 인한 생육촉진 효과는 Golden Melon보다 향맥에서 더욱 뚜렷하였으며, 주효과는 분벽수 증가와 건물중 증가를 용하여 성립되는 경향이었다. 2. 출수현상은 품종 특성에 의하여 주로 결정되는 경향이었고 Golden Melon보다 향맥이 약 1주일정도 빠른 조생성을 보였다. 3. 유효경비율은 품종 특성으로서 질소 반응이 둔하였고 성숙일수는 Golden Melon보다 향맥이 약 1주일정도 길어서 만숙성을 보였으며 양품종 공히 질소 증시로 지연되있다. 4. 대부분의 수량 구성요소들은 그 변이가 품종특성으로 결정되며, 질소 증시의 효과는 혜당입수를 통하여 표현되었다(향맥은 단위면적부 수수 증가도 안정되었다). 5. 수량성은 품종 특성상으로도 향맥이 Golden Melon보다도 높고 시비 질소의 수량화 효율도 향맥이 높은 것으로 판단되었다. 6. 양조 특성의 변이는 주로 질소시비량 차이에 기인되었으며 단백질은 정상관으로, 그리고 탄수화물과 β-Amylase활성은 역상관의 방향으로 변이하였다.